Share Email Print

Proceedings Paper

Towards a Carbon-contamination-tolerant EUV power sensor
Author(s): Jacqueline van Veldhoven; Timo Huijser; Evert Nieuwkoop; Michel van Putten; Norbert Koster; Diederik Maas
Format Member Price Non-Member Price
PDF $14.40 $18.00
cover GOOD NEWS! Your organization subscribes to the SPIE Digital Library. You may be able to download this paper for free. Check Access

Paper Abstract

A reproducible measurement of in-band EUV power over time is essential in EUV lithography, e.g. for dose control, for monitoring the transmission of (parts of) the optical path and for detecting changes in EUV source performance. However, all currently available sensors suffer from sensitivity degradation over time due to photon-induce d contamination and/or structural degradation. For instance, a growing carbon layer on a sensor surface, as may be deposited during exposure to EUV, inhibits detection of an increasingly significant fraction of the EUV power. To minimize a change of sensor response over time, TNO is developing a carbon-contamination-tolerant EUV power sensor that can operate under typical EUV vacuum conditions. The sensor uses the photo-electric effect to distinguish between in- and out-of-band EUV. The sensor concept has been tested in the EUV beam line at TNO using a Xe discharge produced plasma (DPP) EUV source. Here, we present the latest experimental results, showing the time-resolved response of the sensor to the EUV pulse. A spectral purity filter was used to compare the sensor response to the full source spectrum output and to typical Xe DPP EUV emission lines (wavelength range 10-20 nm) only. The EUV signature in the sensor signal was clearly recognizable in both cases. The normalized observed EUV pulse power reproducibility was σ/μ = 23%, reflecting the typical EUV-emission power fluctuations of this Xe DPP EUV source.

Paper Details

Date Published: 4 April 2016
PDF: 8 pages
Proc. SPIE 9776, Extreme Ultraviolet (EUV) Lithography VII, 97762T (4 April 2016); doi: 10.1117/12.2235100
Show Author Affiliations
Jacqueline van Veldhoven, TNO (Netherlands)
Timo Huijser, TNO (Netherlands)
Evert Nieuwkoop, TNO (Netherlands)
Michel van Putten, TNO (Netherlands)
Norbert Koster, TNO (Netherlands)
Diederik Maas, TNO (Netherlands)

Published in SPIE Proceedings Vol. 9776:
Extreme Ultraviolet (EUV) Lithography VII
Eric M. Panning, Editor(s)

© SPIE. Terms of Use
Back to Top